ThePigSite.com - news, features, articles and disease information for the swine industry

News

ATP bioluminescence used to assess trailer cleanliness

12 October 2018

Prairie Swine Centre research publishes a new study documenting the successful use of ATP bioluminescence in efficiently testing trailer hygiene

Authors BZ Predicala, AC Alvarado, and J Cabahug

Abstract

Proper washing and disinfection of swine transport trailers is an important step in maintaining biosecurity. One specific study examined the feasibility of using adenosine triphosphate (ATP) bioluminescence as a rapid and effective swine trailer cleanliness assessment tool. Samples were taken from newly-cleaned, dry trailers using an ATP swab by swabbing an area of 10 cm x 10 cm and were tested for microbial contamination level using an ATP bioluminescence meter.

The results obtained from ATP testing were compared to the co-located samples taken using standard microbiological techniques with MacConkey and R2A agar contact plates (diameter Ø = 60 mm).

From a total of more than 500 samples collected from 16 commercial swine transport trailers across Saskatchewan, a significant correlation (r = 0.206; p=0.001) was found between ATP bioluminescence method and standard microbiological technique using R2A agar plates.

Lower correlation (r = 0.154; p=0.002) was observed between ATP method and MacConkey agar plate counts. Unlike R2A that detects a wider group of bacteria, MacConkey agar supports only the growth of selected gram-negative bacteria while ATP bioluminescence detects ATP from both microbial and organic sources.

Assessing the effectiveness of swine transport trailer cleaning protocol using ATP bioluminescence method threshold values were established with readings of less than 430 RLU per 100 cm2 as ‘Pass’ while higher than 850 RLU per 100 cm2 as ‘Fail’ or has high risk of disease propagation.

Conclusions

• ATP bioluminescence method can be used as a tool for rapid assessment of surface cleanliness of swine transport trailers, complementing the procedures specified in CSHB (2011). Dirty areas in trailers can be rapidly identified using ATP method hence, corrective actions on the current washing/disinfection protocol can be made.

• ATP method had moderate correlation with the standard microbiological method using R2A agar plates; no readily apparent relationship was observed between ATP method and MacConkey agar (MCA) plate counts.

• Results from this study have confirmed that visual inspection of newly cleaned transport trailers is not sufficient in assessing its surface cleanliness because significant levels of ATP and microbial loads were detected on trailer surfaces after cleaning.

• Regardless of the method of assessment used, trailer floors posed the highest risk of microbial contamination among all the six critical areas tested.

 

 

Read the full paper here

 

ThePigSite News Desk

Share This

News By

Related News

More News

Our Sponsors

Partners


Seasonal Picks

Animal Welfare Science, Husbandry and Ethics: The Evolving Story of Our Relationship with Farm Animals