Influence of Dried Distillers’ Grains on Carcass Fat in Swine

Results of their trial led Mickey A. Latour and A. P. Schinckel of the Department of Animal Sciences at Purdue University to conclude that the optimum range for feeding dried distillers' grains (DDGS) is likely to be less than 20 per cent to avoid the pork belly becoming very soft.
calendar icon 18 October 2012
clock icon 5 minute read

Introduction

One of the fastest moving by-products from the production of ethanol in the Midwest is dried distiller's grains with solubles (DDGS). As shown in other Purdue Extension BioEnergy publications, DDGS have high protein and fat content and can be included into a number of livestock and poultry diets. The fat component of DDGS is essentially concentrated corn oil and is known to affect carcass fat softness.

Dietary Intake and Pig Body Composition


Figure 1. Example of a Very Firm Pork Belly, #502 versus Very Soft Belly, #507

Dietary intake plays a major role in determining pig body composition, specifically fat composition because pigs can directly deposit dietary fat into their fat depots. This transfer from diet to body fat is well characterised in grow-finish pigs.

Saturated fatty acids tend to positively influence fat quality by increasing firmness when included in the diet. Conversely, unsaturated fatty acids all tend to negatively affect fat by causing it to have a softer composition. (See Figure 1 for an example of a very firm pork belly and a very soft belly.) Carcasses high in unsaturated fat acids are characterized by higher levels of oxidation, slicing and processing difficulties.

One way to monitor fat firmness is by determining the fatty acid profile and calculating an iodine value (IV). Once the fatty acids have been identified, the IV formula can be applied as follows:

IV = (% C16:1 × 0.950) + (% C18:1 × 0.860) + (% C18:2 × 1.732) + (% C18:3 × 2.616) + (% C20:1 × 0.785) + (% C22:1 × 0.723)

Acceptable IV values vary depending on the processor; however, an IV value over 70 frequently indicates soft fat and a less desirable carcass. The Purdue University laboratory has recently published that the relative abundance of saturated to unsaturated fatty acids may be the best predictor of soft fat tissue but regardless of method, the processor wants non-soft fat tissue in pigs.

DDGS and Pig Fat

So, how does DDGS play a role in pig fat? Again, the fat component of DDGS is concentrated corn oil. So the abundance of C18:2n6 (commonly known as linoleic acid), the primary fatty acid of corn, is very high and a strong contributor to soft fat, as shown in the IV calculation.

In the calculation, (C18:2 is multiplied by 1.732), so if the other fatty acids remain somewhat constant and this one increases by 1.5-fold, then the outcome of IV will go up strongly. Normally, linoleic acid is around 12 per cent of all the fatty acids in pigs (essentially 12×1.732 = 20.78 is the contribution by linoleic acid alone), but when linoleic acid content is increased by 1.5-fold in the carcass through manipulations of diet, one can essentially add 11 IV to the carcass (18 per cent linoleic acid × 1.732 = 31 points — the 20.78 IV points in normal carcass).

Conclusion

The authors' research and that done by others indicates that adding DDGS at 10, 20, 30 or 40 per cent will increase carcass IV, and they believe it is through the relative increase in the level of linoleic acid being consumed. To illustrate the relative change in 'soft belly' fat, click here, where animals were given no DDGS and 10, 20, or 30 per cent DDGS.

The authors also believe from that study along with other work done, that an optimum range for feeding DDGS will most likely be less than 20 per cent inclusion, because that is the point where bellies become noticeably very soft and and normally realise a seven- to 10-point increase in IV. Alternatively, the animals will need to be fed something that counteracts the effects of DDGS, namely Conjugated Linoleic Acid (CLA). Adding one per cent CLA to pig diets can reduce five or six IV points from a pig carcass that had been consuming DDGS.

Thus, feeding DDGS, a common byproduct of ethanol production, to pigs at concentrations of 20 per cent and above will require addition of CLA to the diet in order to maintain acceptable carcass fat firmness. Another important component in feeding DDGS is that all pigs are not equal in terms of fat composition independent of diet. That is, the leaner the genetic population is, the greater the extent to which the pigs' fatty acid profile will be more unsaturated, meaning higher IV, so producers with super genetic lean pigs may need to feed less DDGS compared to other breeds. Additional research must be performed in this area.

October 2012

© 2000 - 2024 - Global Ag Media. All Rights Reserved | No part of this site may be reproduced without permission.